MAINTEX INC -- EXCALIBUR  -- 7930-00N065926
<pre>=====================  Product Identification  =====================

Product ID:EXCALIBUR
MSDS Date:05/06/1990
FSC:7930
NIIN:00N065926
=== Responsible Party ===
Company Name:MAINTEX INC
Address:13300 NELSON AVE
City:CITY OF INDUSTRY
State:CA
ZIP:91746
Country:US
Info Phone Num:818-961-1988
Emergency Phone Num:818-961-1988
Preparer's Name:ATA DANESHRAD
CAGE:0PWJ2
=== Contractor Identification ===
Company Name:MAINTEX INC
Address:13300 NELSON AVE
Box:City:CITY OF INDUSTRY
State:CA
ZIP:91746
Country:US
Phone:818-961-1988
CAGE:0PWJ2

=============  Composition/Information on Ingredients  =============

Ingred Name:AMMONIUM HYDROXIDE (CERCLA)
CAS:1336-21-6
RTECS #:BQ9625000
Fraction by Wt: 0.5-2%
OSHA PEL:50 PPM (MFR)
ACGIH TLV:25 PPM (MFR)
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS

Ingred Name:SUPDAT:NEC. CALL MD. RECS TO MD:DECISION OF WHETHER TO
    INDUCE VOMIT/NOT SHOULD BE MADE BY ATTENDING MD. THERE IS (ING 3)
RTECS #:9999999ZZ

Ingred Name:ING 2:NO SPECIFIC ANTIDOTE. TREATMENT OF OVEREXP SHOULD BE
    DIRECTED AT CONTROL OF SYMPTOMS & THE CLINICAL CONDITION.
RTECS #:9999999ZZ

Ingred Name:SPILL PROC:RECOVERY/DISP & SOLID DIKING MATL TO SEPARATE
    CNTNRS FOR DISP. RINSE AREA & MOP UP. KEEP OUT OF STORM (ING 5)
RTECS #:9999999ZZ

Ingred Name:ING 4:DRAINS, SURF WATER & SOIL. SMALL SPILLS:MOP UP &
    RINSE AREA. PLACE LIQ INTO NON-LEAKING CNTNRS FOR PROPER DISP.
RTECS #:9999999ZZ

Ingred Name:WASTE DISP METH:UNDER APPLIC LAWS & REGS. NOTE:EMPTY CNTNRS
    MAY HAVE PROD RESIDUE, GASES & MISTS & ARE SUBJECT TO(ING 7)
RTECS #:9999999ZZ

Ingred Name:ING 6:PROPER WASTE DISPOSAL. RINSE THOROUGHLY W/WATER &
    SEND TO RECONDITIONER OR DISPOSAL.
RTECS #:9999999ZZ

Ingred Name:OTHER PREC:PRECS GIVEN IN THIS MSDS MUST BE OBSERVED. KEEP
    OUT OF REACH OF CHILDREN. DO NOT TAKE INTERNALLY. (ING 9)
RTECS #:9999999ZZ

Ingred Name:ING 8:MISUSE OF EMPTY CNTNRS CAN BE HAZ. KEEP CNTNR CLSD &
    CAPS, SPOUTS/BUNGS IN PLACE. RECS DESCRIBED HEREIN (ING 10)
RTECS #:9999999ZZ

Ingred Name:ING 9:ARE INTENDED TO PROVIDE GEN GUIDANCE FOR MINIMIZING
    EXPOS & POTNTL RISK WHEN HNDLG THIS PROD. BECAUSE USE (ING 11)
RTECS #:9999999ZZ

Ingred Name:ING 10:CNDTNS WILL VARY DEPENDING W/EACH POSS APPLICATION,
    SPECIFIC SAFE HNDLG PROCS SHOULD BE DEVELOPED BY (ING 12)
RTECS #:9999999ZZ

Ingred Name:ING 11:PERSONS KNOWLEDGEABLE OF INTENDED USE CONDITIONS &
    EQUIPMENT.
RTECS #:9999999ZZ

Ingred Name:EYE PROT:& FULL LENGTH FACESHIELD .
RTECS #:9999999ZZ

Ingred Name:HYGIENE PRACT:SKIN SEVERAL TIMES DAILY ESP BEFORE
    MEALTIMES. LAUNDER/DRY CLEAN SOILED WORK CLTHG DAILY. BEFORE (ING
    15)
RTECS #:9999999ZZ

Ingred Name:ING 14:EATING, DRINKING, SMOKING OR USING TOILET
    FACILITIES, HANDS SHOULD BE WASHED.
RTECS #:9999999ZZ

=====================  Hazards Identification  =====================

LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES  Skin:YES  Ingestion:YES
Reports of Carcinogenicity:NTP:NO    IARC:NO	OSHA:NO
Health Hazards Acute and Chronic:IT IS IMPORTANT TO DETERMINE WHETHER
    EXPOS IS TO CONCENTRATED/DILUTE PROD. INFO INCL IN THIS MSDS IS
    INTENDED TO DEAL W/EXPOS TO CONCENTRATED PROD. GENERALLY, EXPOS TO
    DILUTED PROD WILL RSLT IN SUBSTA NTIALLY LESS RISK OF INJURY THAN
    DESCRIBED HEREIN. ACUTE:EYES:MAY CAUSE BURNS, DMG ESP W/PRLNG CONT.
    (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ:SKIN:CONT W/CONCENTRATE OF SOLN WILL
    RSLT IN DRY SKIN. PRLNG/RPTD CONT MAY CAUSE CRACKING & DERM.
    INHAL:MAY CAUSE BRTHG DFCLTIES, DIZZ/LT IRRIT TO NASAL & RESP
    PASSAGES. INGEST:SWALLOWING MAY  IRRIT THROAT, ESOPHAGUS & DIGEST
    TRACT. CHRONIC:VERY PRLNG EXPOS MAY CAUSE LUNG INFLAMM. OVEREXP MAY
    RSLT IN (SUPDAT)
Medical Cond Aggravated by Exposure:PRE-EXISTING SKIN DISORDERS,
    RESPIRATORY DISEASES. AS W/ANY CHEMICAL, THIS PRODUCT MAY ENHANCE
    ALLERGIC CONDITIONS ON CERTAIN PEOPLE.

=======================  First Aid Measures  =======================

First Aid:EYES:REMOVE CONT LENSES IF WORN. IMMED FLUSH W/PLENTY OF
    WATER FOR AT LST 15 MINS. CALL MD. SKIN:WASH AFFECTED AREA W/SOAP &
    WATER. DO NOT ALLOW CONTAM CLTHG TO REMAIN IN CONT W/SKIN. WASH
    CONTAM CLTH G BEFORE RE-USE. DISCARD CONTAM SHOES IF THEY CANNOT BE
    WASHED. INHAL:REMOVE TO FRESH AIR. IF BRTHG IS DFCLT, GIVE OXYG &
    CALL MD. IF BRTHG STOPS, BEGIN ARTF RESP; IMMED SEEK MED ATTN.
    INGEST:(SUPDAT)

=====================  Fire Fighting Measures  =====================

Flash Point Method:SCC
Flash Point:>212F,>100C
Extinguishing Media:WATER SPRAY, FOAM, CO*2, DRY CHEMICAL.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
    EQUIPMENT .
Unusual Fire/Explosion Hazard:USE WATER FOG/SPRAY TO COOL & LOWER PRESS
    OF FIRE EXPOS CNTNRS TO FLUSH AWAY & TO FLUSH/DILUTE SPILLED MATL.
    HIGH PRESS WATER DIRECTED AT SPILL MAY (SUPP DATA)

==================  Accidental Release Measures  ==================

Spill Release Procedures:WARNING:FLOOR SURF MAY BE SLIPPERY; USE CARE
    WALKING, WORKING & STANDING. LG SPILLS (>55 GALS):WEAR RUBBER
    BOOTS. SHUT OFF SOURCE OF LEAK IF SAFE TO DO SO. DIKE & CONTAIN
    SPILL W/INERT MATL (E.G. SAND , EARTH). TRANSFER LIQ TO CNTNRS FOR
    (ING 4)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

======================	Handling and Storage  ======================

Handling and Storage Precautions:STORE AWAY FROM HEAT, SPKS & OPEN
    FLAME. VENT CNTNR CAREFULLY, AS NEEDED, TO RELIEVE PRESS. KEEP
    CNTNR TIGHTLY CLSD WHEN NOT IN USE.
Other Precautions:DO NOT USE PRESS TO EMPTY CNTNR. DO NOT GET IN EYES,
    ON CLTHG/ON SKIN. DISCARD RAGS, TRASH, ETC SOAKED W/THIS MATL.
    STORE IN ORIGINAL POLYETHYLENE CNTNRS IN COOL, DRY AREA AWAY FROM
    OTHER CHEMS. KEEP  PROD FROM FREEZING. ALL HAZ (ING 8)

=============  Exposure Controls/Personal Protection  =============

Respiratory Protection:WHERE EXPOSURE LIMITS ARE EXCEEDED USE
    NIOSH/MSHA APPROVED RESPIRATOR.
Ventilation:MECHANICAL LOCAL EXHAUST VENTILATION AT POINT OF
    CONTAMINANT RELEASE.
Protective Gloves:RUBBER GLOVES.
Eye Protection:ANSI APPROVED CHEM WORKERS GOGGS(ING 13)
Other Protective Equipment:EYE WASH FOUNTAIN & DELUGE SHOWER WHICH MEET
    ANSI DESIGN CRITERIA .
Work Hygienic Practices:WASH THORO AFTER HNDLG. EXPOS EMPLOYEES SHOULD
    EXERCISE REAS PERSONAL CLEANLINESS; THIS INCLS CLEANSING EXPOS (ING
    14)
Supplemental Safety and Health
PH:9.5-10.5. EXPLO HAZ:CAUSE FOAMING. EFTS OF OVEREXP:ALLERGIC SKIN
    RXNS. FIRST AID PROC:GIVE PLENTY OF WATER. DECISION TO INDUCE VOMIT
    SHOULD BE MADE BY MD. WASH OUT MOUTH AREA. NEVER GIVE ANYTHING B Y
    MOUTH TO UNCON PERS. IF VOMIT OCCURS SPONT GIVE FLUIDS AGAIN. HAVE
    MED PERS DETERMINE IF EVACUATION OF STOM IS (ING 2)

==================  Physical/Chemical Properties  ==================

Boiling Pt:B.P. Text:>212F,>100C
Melt/Freeze Pt:M.P/F.P Text:40.0F,4.4C
Vapor Pres:<17 @ 68F
Vapor Density:>1
Spec Gravity:1.1
pH:SUPDAT
Evaporation Rate &amp; Reference:<1 (BUTYL ACETATE=1)
Solubility in Water:DISPERSES
Appearance and Odor:THICK TAN PASTE; AMMONIACAL ODOR.
Percent Volatiles by Volume:57(WT)

=================  Stability and Reactivity Data  =================

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS.
Stability Condition to Avoid:HEAT, SPARKS, OPEN FLAME.
Hazardous Decomposition Products:CARBON & NITROGEN OXIDES.

====================  Disposal Considerations  ====================

Waste Disposal Methods:LANDFILL CONTAM ABSORB. AVOID LANDFILLING LIQS.
    SM AMTS MAY BE DISP OF IN SEWER IF DILUTED W/SUFFICIENT DILUTION
    WATER. DISP OF WASTES I/A/W FED, STATE & LOC REGS. IN EVENT OF
    UNCONTROLLED RELS, USER  SHOULD DETERMINE IF RELS IS REPORTABLE
    (ING 6)

 Disclaimer (provided with this information by the compiling agencies):
 This information is formulated for use by elements of the Department
 of Defense.  The United States of America in no manner whatsoever,
 expressly or implied, warrants this information to be accurate and
 disclaims all liability for its use.  Any person utilizing this
 document should seek competent professional advice to verify and
 assume responsibility for the suitability of this information to their
 particular situation.